|
|
|
|
|
Engine
Compartment |
|
|
Firewall |
|
|
|
Instrument
Panel |
|
|
|
|
|
Airframe |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Firewall Connector |
|
|
|
|
|
|
|
|
Pin Numbers |
|
|
|
|
|
|
Compass Lt |
|
|
#16 |
|
|
|
|
|
|
|
|
|
RPM |
|
Fuel Pres |
|
|
1A Fuse |
|
|
|
|
|
Battery |
|
|
|
|
|
|
|
|
|
|
|
|
typical Ground for Instr. Pwr |
|
|
#4 |
|
Shunt |
|
|
|
|
|
|
Instr. Pwr. And Lighting |
|
|
|
|
25 A |
|
Generator |
|
|
all Instruments |
|
|
|
|
Generator |
|
|
|
|
#S20 |
|
Oil Temp |
|
|
#4 |
|
|
#10 |
|
|
|
I |
I |
|
|
Battery
Relais |
|
|
|
|
|
Master Switch |
|
N |
N |
|
Note 1: |
|
|
#4 |
|
|
|
|
|
|
0,25 A |
S |
S |
|
Wire Sizes in # Number of AWG
Size |
|
|
|
#16 |
|
|
|
Fuse |
T |
T |
|
Note 2: |
|
|
#16 |
|
|
|
|
|
R |
R |
|
V/A Meter |
|
Shielded Wire Sizes
in # S Number of AWG Size |
|
|
|
1 Gen Amp |
|
|
|
#16 |
|
U |
U |
|
Note 3: |
|
|
|
2 Bat Volt |
|
|
|
#10 |
|
M |
M |
|
Antenna Cables are 50 Ohm
RG400 |
|
|
|
|
|
|
E |
E |
|
Note 4: |
|
|
|
|
1,5
V Bat OAT/Sensor on left Gear |
|
|
N |
N |
|
Grounding Wires same AWG
or one Size lower then feeder |
|
#4 |
|
|
|
|
|
#22 |
|
T |
T |
|
Fuel Qty |
|
Note 5: |
|
|
Start |
|
|
|
|
|
Clock |
|
|
|
CHT Temp Probe Wires
(from Cyl Head to Switch) |
|
|
Motor |
|
|
|
|
|
L |
P |
|
are specially calibrated
Westach Wires. Do not splice! |
|
|
#10 |
|
|
|
I |
O |
|
|
Starter |
|
|
|
|
H |
W |
|
|
Relay |
|
|
|
|
Off R |
|
G |
E |
|
Carb Tep |
|
|
#16 |
|
+/- |
|
|
|
R |
|
T |
R |
|
|
~ |
|
|
|
Both |
|
I |
|
|
Main |
|
|
|
25 A |
|
Start |
|
N |
|
|
Generator |
|
1 |
|
Recitifier |
|
|
|
Starter |
|
Off L |
|
G |
|
|
20A |
|
|
|
|
|
|
L |
|
|
|
Oil Pres |
|
|
|
|
|
|
|
Both |
|
|
|
|
2 |
|
|
#16 |
|
53 & 55 Spare |
|
|
M |
|
Start |
#10 |
|
|
|
|
|
|
|
A |
|
|
|
|
|
I |
|
Mag / Start Switch |
|
Cyl Head |
|
|
|
|
|
N |
#S16 |
|
#22 |
#2 |
0 |
Temp |
|
|
Fuel Pump Rectifier |
|
|
|
|
|
|
|
PSD 25/02 |
|
|
|
|
|
B |
|
#20 |
|
|
Primary |
|
|
5A Sec |
U |
5A |
|
B |
#22 |
|
|
Fuel Pump |
|
|
Fuel Pump |
S |
Eng. Instr. |
|
G |
#22 |
|
|
|
|
|
|
|
O |
#22 |
|
|
#S16 |
|
|
|
|
|
|
#20 |
|
|
|
|
Switch |
|
1A |
|
|
Spark Plugs |
Coils |
|
|
8 Sec Fuel Pump |
#16 |
|
|
|
Trim & |
|
|
1 |
1 |
|
#22 |
Sec Ign |
|
|
|
|
|
ELT |
|
Trim Indicator |
|
|
Magneto |
|
Pick-up |
|
|
|
|
|
|
|
#20 |
|
|
Prim Ign |
3 |
3 |
1 & 3 |
|
Secondary |
|
5A Sec |
|
|
|
|
|
2 |
2 |
2 & 4 |
|
|
|
Fuel
Pump |
|
Ignition |
|
|
|
#20 |
|
|
|
|
#22 |
|
|
|
|
|
|
|
4 |
4 |
|
|
|
#S16 |
|
|
|
|
|
|
|
Switch |
|
|
Trim Switch |
|
Trim Servo |
|
|
|
|
|
|
|
Pilot Control Stick |
|
Left Elevator |
|
|
|
|
|
|
|
20 Fuel Pressure |
|
|
|
|
#22 |
|
|
|
|
|
|
|
3 Oil Temp |
|
|
|
#22 |
|
|
T |
|
P |
|
|
|
|
#22 |
|
|
|
Carb Heat 6 white / 7
black |
|
|
#22 |
|
|
|
5
Oil Pressure / 54 Low Oil Px Wng Light |
|
Low Oil Pressure Warning Light |
|
#22 |
|
|
|
|
|
|
#22 |
|
|
|
|
|
|
Emergency
Locator |
|
Remote Sw |
|
#20 |
|
|
|
|
|
|
Transmitter
(ELT) |
|
|
|
Cyl Nr |
|
|
#S20 |
|
|
|
|
|
|
|
1 |
|
Lft Strobe |
|
Rt Strobe |
|
|
|
|
|
|
|
|
|
2 |
|
Contr Box |
|
Contr Box |
|
|
|
|
|
|
|
|
|
3 |
|
#S20 |
|
Right Wingtip Strobe Light |
|
|
T |
|
|
|
|
|
4 |
|
|
|
|
|
|
|
|
#20 |
|
Tail Light (white) |
|
|
|
|
|
|
|
|
Cyl Head Temp |
|
|
P |
|
|
|
|
|
|
Selector Switch |
|
Left Wing Light (red) |
|
|
|
|
|
|
|
#20 |
|
|
|
Cyl 1 |
|
|
|
|
5A Sec |
M |
15A |
|
Right Wing Light (green) |
|
Left Wingtip Strobe Light |
|
|
|
|
|
|
CHT Wire see Note 5 |
|
|
|
TXP & Enc |
A |
Strobe |
|
#20 |
|
|
Cyl 4 |
|
Cyl 3 |
|
|
|
|
|
|
#20 |
I |
|
#16 |
|
Landing Light |
|
|
Cyl 2 |
|
|
|
|
5A VHF Intc |
N |
5A |
|
|
|
|
|
|
|
Ldg Nav Lt |
|
Landing Light / Nav Light Sw |
|
Wiring Diagram |
|
|
|
|
|
|
B |
|
#22 |
|
Aircraft: |
KR-2S |
|
|
|
Altitude |
Trans- |
|
#20 |
U |
5A |
|
Serial Nr.: |
8739-285 |
|
|
|
Encoder |
ponder |
|
5A Turn |
S |
Stall Wng |
|
Stall |
Stall Wng Sw |
|
|
|
|
|
|
|
Coord |
|
|
Horn |
Left Wing |
|
Revision 0 |
|
|
|
|
Inter- |
VHF |
|
|
|
|
Date |
July 2002 |
|
|
|
comm |
Radio |
|
|
VHF Radio PTT |
|
Builder: |
|
|
|
|
|
|
All Intercom Wires #22 |
|
Control Stick |
|
Christian Kogelmann |
|
|
|
|
Turn
Coordinator |
|
|
Robert Wanek |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|